Development and optimization of danazol co-crystal loaded tablet to treat endometriosis
DOI:
https://doi.org/10.56782/pps.525Keywords:
danazol, co-crystallization, solubility enhancement, factorial design, endometriosisAbstract
Objectives: To develop, optimize, and characterize danazol co-crystal-loaded tablets for enhanced solubility and dissolution in order to improve therapeutic efficacy in endometriosis treatment. Methods: Danazol co-crystals were prepared using various co-formers through a solvent evaporation technique and characterized by FTIR, DSC, and XRD. Co-crystals were formulated into tablets using direct compression and optimized through a 3² factorial design, varying sodium croscarmellose (8—24 mg) and PVP K-30 (4—20 mg) concentrations. Formulations were evaluated for pre-compression properties, physical parameters, disintegration, dissolution, and stability. Results: Danazol-malonic acid co-crystals (1:2 ratio) exhibited the highest solubility enhancement (11.42 ± 0.53 μg/mL, 13.76-fold increase). XRD confirmed the formation of a new crystalline phase with distinct peaks at 19° and 21° 2θ. The quadratic models for both disintegration time (R² = 0.9971) and drug release (R² = 0.9483) demonstrated excellent predictive capability. Formulation VF7 (24 mg sodium croscarmellose, 4 mg PVP K-30) was identified as optimal with rapid disintegration (74.0 ± 3.2 seconds) and superior dissolution (83.6 ± 3.4% at 30 minutes, 95.8 ± 2.0% at 60 minutes) compared to the marketed product (75.2 ± 2.7% at 60 minutes). The optimized formulation maintained stability under accelerated conditions (40°C/75% RH) for three months. Conclusion: The optimized danazol co-crystal tablet formulation successfully overcame the solubility and dissolution limitations of this poorly soluble drug, potentially enhancing bioavailability and therapeutic efficacy while reducing dosing frequency for endometriosis patients. This approach presents a promising platform for improving clinical outcomes and patient compliance in endometriosis management.
Downloads
References
1. Horan, M. Fertility Preservation in Young Women at Risk of Ovarian Insufficiency Due to Malignancy or Endometriosis. PhD Thesis, University College Dublin, Dublin, Ireland, 2022. Available online: https://researchrepository.ucd.ie/entities/publication/1f82a048-f329-4e50-9629-ffbb5f6ca300 (accessed on 20 May 2025).
2. Missmer, S.A.; Tu, F.F.; Agarwal, S.K.; Chapron, C.; Soliman, A.M.; Chiuve, S.; Eichner, S.; Flores-Caldera, I.; Horne, A.W.; Kimball, A.B.; et al. Impact of Endometriosis on Life-Course Potential: A Narrative Review. Int. J. Gen. Med. 2021, 14, 9–25. DOI: 10.2147/IJGM.S261139
3. Bonavina, G.; Taylor, H.S. Endometriosis-Associated Infertility: From Pathophysiology to Tailored Treatment. Front. Endocrinol. 2022, 13, Art. No: 1020827. DOI: 10.3389/fendo.2022.1020827
4. Adokiye, E.A. Effects of Endometriosis on Quality of Life (Benefit of Combined Hystero-Laparoscopic Surgery on Quality of Life and Fertility Performance in Endometriosis). Doctoral (PhD) Thesis, University of Pécs, Pécs, Hungary, 2024.
5. Donnez, J.; Cacciottola, L.; Squifflet, J.-L.; Dolmans, M.-M. Profile of Linzagolix in the Management of Endometriosis, Including Design, Development and Potential Place in Therapy: A Narrative Review. Drug Des. Dev. Ther. 2023, 17, 369–380. DOI: 10.2147/DDDT.S269976
6. Fuqua, J.S.; Eugster, E.A. History of Puberty: Normal and Precocious. Horm. Res. Paediatr. 2022, 95, 568–578. DOI: 10.1159/000525386
7. Gonçalves, M.D.; Tomiotto-Pellissier, F.; De Matos, R.L.N.; Assolini, J.P.; Da Silva Bortoleti, B.T.; Concato, V.M.; Silva, T.F.; Rafael, J.A.; Pavanelli, W.R.; Conchon-Costa, I.; et al. Recent Advances in Biotransformation by Cunninghamella Species. Curr. Drug Metab. 2021, 22, 1035–1064. DOI: 10.2174/1389200222666211126100023
8. Al-Badr, A.A. Chapter Five – Danazol. In Profiles of Drug Substances, Excipients and Related Methodology; Al-Majed, A.A., Ed.; Academic Press: Cambridge, MA, USA, 2022; Volume 47, pp. 149–326. DOI: 10.1016/bs.podrm.2021.10.005
9. Huang, H.-E.; Lin, K.-M.; Lin, J.-C.; Lin, Y.-T.; He, H.-R.; Wang, Y.-W.; Yu, S.-F.; Chen, J.-F.; Cheng, T.-T. Danazol in Refractory Autoimmune Hemolytic Anemia or Immune Thrombocytopenia: A Case Series Report and Literature Review. Pharmaceuticals 2022, 15, Art. No: 1377. DOI: 10.3390/ph15111377
10. Riva, M.; Bosi, A.; Rizzo, L.; Mazzon, F.; Ferrari, S.; Lussana, F.; Borin, L.; Castelli, A.; Cairoli, R.; Barcellini, W.; et al. Danazol Treatment for Thrombocytopenia in Myelodysplastic Syndromes: Can an “Old-Fashioned” Drug Be Effective? HemaSphere 2023, 7, Art. No: e867. DOI: 10.1097/HS9.0000000000000867
11. Nyamba, I.; Sombié, C.B.; Yabré, M.; Zimé-Diawara, H.; Yaméogo, J.; Ouédraogo, S.; Lechanteur, A.; Semdé, R.; Evrard, B. Pharmaceutical Approaches for Enhancing Solubility and Oral Bioavailability of Poorly Soluble Drugs. Eur. J. Pharm. Biopharm. 2024, 204, Art. No: 114513. DOI: 10.1016/j.ejpb.2024.114513
12. Madhuri, G.; Nagaraju, R. An Overview on Novel Particle Engineering Designing: Co-Crystallization Techniques. Int. J. Pharm. Sci. Rev. Res. 2021, 66, 88–101. DOI: 10.47583/ijpsrr.2021.v66i01.015
13. Jadhav, S.P.; Chaudhari, K.R.; Nikam, K.R.; Salunkhe, K.S.; Chaudhari, S.R. Co-Crystal: An Emerging Trend in Pharmaceuticals. Inventi Rapid: NDDS 2012, 2012(3), 1–6.
14. Dhondale, M.R.; Thakor, P.; Nambiar, A.G.; Singh, M.; Agrawal, A.K.; Shastri, N.R.; Kumar, D. Co-Crystallization Approach to Enhance the Stability of Moisture-Sensitive Drugs. Pharmaceutics 2023, 15, Art. No: 189. DOI: 10.3390/pharmaceutics15010189
15. Bhatia, M.; Kumar, A.; Verma, V.; Devi, S. Development of Ketoprofen-p-Aminobenzoic Acid Co-Crystal: Formulation, Characterization, Optimization, and Evaluation. Med. Chem. Res. 2021, 30, 2090–2102. DOI: 10.1007/s00044-021-02794-7
16. Tatsumi, Y.; Shimoyama, Y.; Kazarian, S.G. Analysis of the Dissolution Behavior of Theophylline and Its Cocrystal Using ATR-FTIR Spectroscopic Imaging. Mol. Pharm. 2024, 21, 3233–3239. DOI: 10.1021/acs.molpharmaceut.4c00002
17. Zhang, H.; Zeng, H.; Li, M.; Song, Y.; Tian, S.; Xiong, J.; He, L.; Liu, Y.; Wu, X. Novel Ascorbic Acid Co-Crystal Formulations for Improved Stability. Molecules 2022, 27, Art. No: 7998. DOI: 10.3390/molecules27227998
18. Chettri, A.; Subba, A.; Singh, G.P.; Bag, P.P. Pharmaceutical Co-Crystals: A Green Way to Enhance Drug Stability and Solubility for Improved Therapeutic Efficacy. J. Pharm. Pharmacol. 2024, 76, 1–12. DOI: 10.1093/jpp/rgad097
19. Al-Nimry, S.S.; Khanfar, M.S. Enhancement of the Solubility of Asenapine Maleate Through the Preparation of Co-Crystals. Curr. Drug Deliv. 2022, 19, 788–800. DOI: 10.2174/1567201818666210805154345
20. Huang, Z.; Staufenbiel, S.; Bodmeier, R. Combination of Co-Crystal and Nanocrystal Techniques to Improve the Solubility and Dissolution Rate of Poorly Soluble Drugs. Pharm. Res. 2022, 39, 949–961. DOI: 10.1007/s11095-022-03243-9
21. Ji, X.; Wu, D.; Li, C.; Li, J.; Sun, Q.; Chang, D.; Yin, Q.; Zhou, L.; Xie, C.; Gong, J.; et al. Enhanced Solubility, Dissolution, and Permeability of Abacavir by Salt and Cocrystal Formation. Cryst. Growth Des. 2022, 22, 428–440. DOI: 10.1021/acs.cgd.1c01051
22. Nadh, T.V.H.H.; Kumar, P.S.; Ramana, M.V.; Rao, N.R. Formulation and Optimization of Zolmitriptan Orodispersible Tablets. J. Drug Deliv. Ther. 2021, 11, 50–58. DOI: 10.22270/jddt.v11i3.4703
23. Kumar, S.; Sharma, P. Factorial Design Optimization in Pharmaceutical Formulations. Asian J. Res. Chem. 2021, 14, 245–252.
24. Jadhav, S.; Patil, M. Formulation of Tablet of Ivermectin Co-Crystal for Enhancement of Solubility and Other Physical Properties. Res. J. Pharm. Technol. 2023, 16, 1245–1252.
25. Abdelrahman, H.; Essa, E.; Maghraby, G.E.; Arafa, M. L-Proline as Co-Crystal Forming Amino Acid for Enhanced Dissolution Rate of Lamotrigine: Development of Buccal Tablet. Indones. J. Pharm. 2023, 34, 574–583. DOI: 10.22146/ijp.6867
26. Eidevåg, T.; Thomson, E.S.; Kallin, D.; Casselgren, J.; Rasmuson, A. Angle of Repose of Snow: An Experimental Study on Cohesive Properties. Cold Reg. Sci. Technol. 2022, 194, Art. No: 103470. DOI: 10.1016/j.coldregions.2021.103470
27. Singh, A.; Patel, R. Powder Flow Characterization in Pharmaceutical Manufacturing. Res. J. Pharm. Technol. 2021, 14, 156–162.
28. Al-Dulaimi, A.F.; Al-Kotaji, M.; Abachi, F.T. Paracetamol/Naproxen Co-Crystals: A Simple Way for Improvement of Flowability, Tableting and Dissolution Properties. Iraqi J. Pharm. Sci. 2021, 30, 45–55.
29. Botella-Martínez, C.; Viuda-Martos, M.; Fernández-López, J.A.; Pérez-Alvarez, J.A.; Fernández-López, J. Development of Plant-Based Burgers Using Gelled Emulsions as Fat Source and Beetroot Juice as Colorant. LWT 2022, 172, Art. No: 114193. DOI: 10.1016/j.lwt.2022.114193
30. Simão, J.; Chaudhary, S.A.; Ribeiro, A.J. Implementation of Quality by Design (QbD) for Development of Bilayer Tablets. Eur. J. Pharm. Sci. 2023, 184, Art. No: 106412. DOI: 10.1016/j.ejps.2023.106412
31. Ficzere, M.; Mészáros, L.A.; Kállai-Szabó, N.; Kovács, A.; Antal, I.; Nagy, Z.K.; Galata, D.L. Real-Time Coating Thickness Measurement and Defect Recognition of Film-Coated Tablets with Machine Vision and Deep Learning. Int. J. Pharm. 2022, 623, Art. No: 121957. DOI: 10.1016/j.ijpharm.2022.121957
32. Momeni, M.; Afkanpour, M.; Rakhshani, S.; Mehrabian, A.; Tabesh, H. Prediction Model Based on Artificial Intelligence Techniques for Disintegration Time and Hardness of Fast Disintegrating Tablets. BMC Med. Inform. Decis. Mak. 2024, 24, Art. No: 88. DOI: 10.1186/s12911-024-02485-4
33. Zhao, H.; Yu, Y.; Ni, N.; Zhao, L.; Lin, X.; Wang, Y.; Du, R.; Shen, L. New Parameter for Characterization of Tablet Friability. Int. J. Pharm. 2022, 611, Art. No: 121339. DOI: 10.1016/j.ijpharm.2021.121339
34. Berardi, A.; Bisharat, L.; Quodbach, J.; Abdel Rahim, S.; Perinelli, D.R.; Cespi, M. Advancing the Understanding of Tablet Disintegration Phenomenon. Int. J. Pharm. 2021, 598, Art. No: 120390. DOI: 10.1016/j.ijpharm.2021.120390
35. Farquharson, A.; Gladding, Z.; Ritchie, G.; Shende, C.; Cosgrove, J.; Smith, W.; Brouillette, C.; Farquharson, S. Drug Content Uniformity Using Raman Spectroscopy. Pharmaceutics 2021, 13, Art. No: 309. DOI: 10.3390/pharmaceutics13030309
36. Chakraborty, S.; Mondal, D.S. Green Eco-Friendly Analytical Method Development of Favipiravir. Int. J. Pharm. Investig. 2023, 13, 290–305. DOI: 10.5530/ijpi.13.2.039
37. González-González, O.; Ramirez, I.O.; Ramirez, B.I.; O'Connell, P.; Ballesteros, M.P.; Torrado, J.J.; Serrano, D.R. Drug Stability: ICH versus Accelerated Predictive Stability Studies. Pharmaceutics 2022, 14, Art. No: 2324. DOI: 10.3390/pharmaceutics14112324
38. Parvarinezhad, S.; Salehi, M.; Kubicki, M.; Eshaghi Malekshah, R. Noncovalent Interactions in Co-Crystal of μ-Oxobridged Polymeric Copper(II) Complex. J. Mol. Struct. 2022, 1260, Art. No: 132780. DOI: 10.1016/j.molstruc.2022.132780
39. Rojek, B.; Bartyzel, A.; Leyk, E.; Plenis, A. Arbidol Hydrochloride Compatibility Study Using DSC, FTIR, TGA-FTIR, and PXRD. J. Therm. Anal. Calorim. 2025, 152, 1–15. DOI: 10.1007/s10973-025-14056-4
40. Farag Badawy, S.I.; Ghorab, M.M.; Adeyeye, C.M. Characterization and Bioavailability of Danazol–Hydroxypropyl β-Cyclodextrin Coprecipitates. Int. J. Pharm. 1996, 128, 45–54. DOI: 10.1016/0378-5173(95)04214-8
41. Bhalani, D.V.; Nutan, B.; Kumar, A.; Singh Chandel, A.K. Bioavailability Enhancement Techniques for Poorly Aqueous Soluble Drugs. Biomedicines 2022, 10, Art. No: 2055. DOI: 10.3390/biomedicines10092055
42. Han, J.; Li, L.; Su, M.; Heng, W.; Wei, Y.; Gao, Y.; Qian, S. Deaggregation and Crystallization Inhibition in Co-Amorphous Systems. Pharmaceutics 2021, 13, Art. No: 1725. DOI: 10.3390/pharmaceutics13101725
43. Adama, J.C.; Arocha, C.G.; Ogbobe, P.O. Physical Properties of Oil Palm Kernels. Niger. J. Technol. 2022, 41, 365–369. DOI: 10.4314/njt.v41i2.18
44. Kole, S.; Vinchurkar, R.; Gawade, A.; Kuchekar, A. Impact of Co-Crystal Formation on Stability of Camylofin Tablets. Hacet. Univ. J. Fac. Pharm. 2024, 44, 108–123. DOI: 10.52794/hujpharm.1331991
45. Lovanov, R.; Cornilă, A.; Bogdan, C.; Hales, D.; Tomuță, I.; Achim, M.; Tăut, A.; Iman, N.; Casian, T.; Iurian, S. Disintegration and Texture-Related Palatability of Orodispersible Tablets. Eur. J. Pharm. Sci. 2024, 198, Art. No: 106801. DOI: 10.1016/j.ejps.2024.106801
46. Devi, S.; Kumar, A.; Kapoor, A.; Verma, V.; Yadav, S.; Bhatia, M. Ketoprofen–FA Co-Crystal: In Vitro and In Vivo Investigation. AAPS PharmSciTech 2022, 23, Art. No: 101. DOI: 10.1208/s12249-022-02253-5
47. Zarrik, B.; El Amri, A.; Bensalah, J.; Jebli, A.; Lebkiri, A.; Hsissou, R.; Hbaiz, E.M.; Rifi, E.H.; Lebkiri, A. Adsorption of Crystal Violet Using Graphene Oxide Composite. Inorg. Chem. Commun. 2024, 162, Art. No: 112179. DOI: 10.1016/j.inoche.2024.112179
48. Mazloomi, S.; Amarloei, A.; Gholami, F.; Haghighat, G.A.; Badalians Gholikandi, G.; Nourmoradi, H.; Mohammadi, A.A.; Fattahi, M.; Nguyen Le, B. Process Modeling for Metronidazole Removal by ZIF-67 Crystals. Sci. Rep. 2023, 13, Art. No: 14654. DOI: 10.1038/s41598-023-41724-y
49. Ruhil, S.; Dahiya, M.; Kaur, H.; Singh, J. Disintegration Profiling of Rapidly Disintegrating Tablets by Thermal Imaging. Int. J. Pharm. 2022, 611, Art. No: 121283. DOI: 10.1016/j.ijpharm.2021.121283
50. Hu, C.; Zhang, F.; Fan, H. Evaluation of Drug Dissolution in Co-Amorphous and Co-Crystal Systems. AAPS PharmSciTech 2021, 22, Art. No: 21. DOI: 10.1208/s12249-020-01864-0
51. Janilkarn-Urena, I.; Tse, A.; Lin, J.; Tafolla-Aguirre, B.; Idrissova, A.; Zhang, M.; Skinner, S.G.; Mostowfi, N.; Kim, J.; Kalapatapu, N.; et al. Improving Solubility of Pseudo-Hydrophobic Chemicals through Co-Crystal Formulation. PNAS Nexus 2025, 4, Art. No: pgaf007. DOI: 10.1093/pnasnexus/pgaf007
52. Orszulak, L.; Włodarczyk, P.; Hachuła, B.; Lamrani, T.; Jurkiewicz, K.; Tarnacka, M.; Hreczka, M.; Kamiński, K.; Kamińska, E. Inhibition of Naproxen Crystallization by Polymers. Eur. J. Pharm. Biopharm. 2025, 207, Art. No: 114581. DOI: 10.1016/j.ejpb.2024.114581
53. Jadhav, S.P.; Ahire, S.M.; Shewale, V.V.; Patil, C.D.; Pagar, R.Y.; Sonawane, D.D.; et al. Formulation of Tablet of Nifedipine Co-Crystal for Enhancement of Solubility. Biosci. Biotechnol. Res. Asia 2025, 22(1), 191–200. DOI: 10.13005/bbra/3353
Downloads
Published
Issue
Section
License
Copyright (c) 2025 Vidya Patil

This work is licensed under a Creative Commons Attribution 4.0 International License.
For all articles published in Prospects in Pharmaceutical Sciences copyright is retained by the authors. The journal publishes articles in the Open Access policy, within the CC BY 4.0 licence.
This is a human-readable summary of (and not a substitute for) the license. Disclaimer.
You are free to:
Share — copy and redistribute the material in any medium or format
Adapt — remix, transform, and build upon the material for any purpose, even commercially.
The licensor cannot revoke these freedoms as long as you follow the license terms.
Under the following terms:
Attribution — You must give appropriate credit, provide a link to the license, and indicate if changes were made. You may do so in any reasonable manner, but not in any way that suggests the licensor endorses you or your use.
No additional restrictions — You may not apply legal terms or technological measures that legally restrict others from doing anything the license permits.
Notices:
You do not have to comply with the license for elements of the material in the public domain or where your use is permitted by an applicable exception or limitation.
No warranties are given. The license may not give you all of the permissions necessary for your intended use. For example, other rights such as publicity, privacy, or moral rights may limit how you use the material.